Primary Role

The Water Treatment Operator is responsible for plant operations, analyzing water samples and making needed adjustments. 

Key Accountabilities

• Performs chemical treatment duties which include the following.
• Walks to the carbon feed room.
• Must walk up/down flights of stairs with railing.
•  Must be wearing appropriate safety apparel.
• Reaches up to 76" to open door and lower it.
• Requires 25 lb. force to lower door.
• Lifts 50 lb. bag of powdered activated carbon from pallet.
• Can be stacked from 6" to 53" high.
• Truck flexion and/or squatting, forward reaching, lifting from floor to waist height.
• Can use pallet jack to raise pallet height so that all lifting is done at waist height.
• Pushing down on pallet jack handle.
• Places back on door.
• Uses utility knife to open bag.
• Hits end of poker with palm of hand to pierce bag (wrist
  extension, elbow flexion/ext) Lift door back into position.
• Lifting 75 lbs. force from below waist to overhead.
•  Fills potassium permanganate.
• Uses the dolly to move full barrel to location.
• 30 lb. force required to pull back dolly to move barrel.
• Uses scoop (7times) to put powder into the container.
• Each scoop weighs approximately 3 lbs.
• Trunk flexion and reaching down into the barrel, gripping and wrist deviations.
• Tool used are gloves, apron, respirator, utility knife, poker, pallet jack.

Key Accountabilities (continued)

Performs cleaning daily as needed which include the following:

• Responsible for cleaning lab and computer area. This task requires standing, walking and going up/down stairs.
• Sweeps and mops the floor.
• Trunk and neck flexion, trunk rotation and gripping of handle, elbow flexion and extension. Washes glassware in the lab-slight trunk flexion, grip, material handling less than 5#. May squat or reach
  overhead to put away glassware.
• Shovels walkway and steps as needed.
• May be walking on slippery surfaces. Tools used are cleaning supplies, mop, broom and shovel. (%)
• Occasionally on a daily basis uses a computer which include the following: Seated task which includes data entry and uses mouse and keyboard to turn pumps on and off. Fine motor coordination task and
  slight neck flexion and rotation to look at the computer screens.

• Performs sample collection occasionally on a daily basis which include the following: Walks outside in all weather conditions to the basin.
• Must walk up/down flight of stairs. Carries two plastic pipes (2# each) and 3 plastic bottles to the basin. Screws the bottle on the end of the
  pipe (wrist deviation and forearm rotation).
• Lowers pipe to the bottom of the basin, trunk and neck flexion, forward reaching.
• Pulls out sample and unscrew bottle fro the pipe.
• Walks to other basins and repeats the process.
• Tools used are plastic collection pipe (2#), sample bottles. (%)

Analyzes samples occasionally on a daily basis which include the following:

• Works standing at lab table 36" high.
• Constant standing obtain glassware from shelving (weighs less than 2#).
• May have to side with occasional walking short distances.
• May have to reach overhead to bend with trunk flexion and/or squat to obtain items from lower shelving.
• Pours samples into beakers, wrist deviation, shoulder flexion gripping.
• Pours packets into samples and swirls beakers to mix.
• Gripping with wrist deviation.
• Places samples into analyzers and pushes buttons to start. This task may require neck flexion, trunk flexion and forward reaching.
• May lift a full water pitcher 10 lbs. to fill equipment once daily.
• Tools used: measuring devices (beakers, test tubes), analyzers, microscope, pipettes, ladder on the outside of the tank. 
• Lifts up cover (10 lbs.) from the tank.
• Puts measuring tape into the tank, neck flexion, forward reaching. 
• Tools used: measuring tape and ladder 
• Measures the level of acid tanks

Knowledge/Skills

• Mechanical aptitude
• Water Operator experience is a plus
• Ability to work independently 

Experience/Education

• High school diploma or equivalent education degree (GED) 

Work Schedule

• Full-time, On-site
• Rotating schedule- 7pm-7am

Competencies